The magnetos installed on my IO-360-M1B Lycoming engine are as follows:
Left magneto: SN: 13050795, M-2983LH, Model: 4373
Right magneto: SN: 13050824, Model: 4370
According to Lycoming operator’s manual, the left magneto should be model 4371.
Slick/Champion service bulletin SB1-12 (corrected copy) is not applicable (SNs: 11110001 thru 12030902).
Magneto gasket part number: 62224?
Slick Mag gasket part number: LW-12681 (need 2 for impulse mag side)
Update checklist & laminate
Add toolkit to plane
Make a POH
Install upper cowl air ramps
Install co-pilot stick
Do best glide speed test
Do max speed test
Install spare fuses
Calibrate AoA Probe
Block some of the heater air inlet to slow the heater air and keep more pressure in upper cowl
Wire fuses or fuseible link for ammeter shunt
Install prop leading edge tape
Get repariman certificate
Repair passenger side canopy air seal weatherproofing
Install IFR GPS Databases
Block more of the oil cooler
Download flight 6 data
Tape over the holes in the belly that may let fumes in
Get G3X Lean assist mode working/enabled
Install nutplates for 2 extra screws for upper landing gear fairing
Prime the spinner to protect from UV
Mount 1.3 lb. halon fire extinguisher
Mount the PLB
Register the PLB
Check EFIS V-speeds
Add checklist to phone
Test GoPro ships power
Test GoPro aviation radio audio
Get Iphone mount
Install wire booties to protect magneto P-leads
Order & install aileron pushrod boots (to prevent cold air infiltration)
Install autopilot roll servo
Connect autopilot pitch servo actuator arm
Glue canopy fiberglass front lip split
Install dynon d6 compass
Buy tire air filler extension
Left front cylinder, 1 engine bolt weeping oil (1 drop per hour)
Organize flight logs/receipts
Caulk or firedip the firesleeve ends
Buy Hoppe #9 Gun Cleaning Solvent for cleaning the injectors
Buy ultrasonic cleaner
Fold safety wire & cut clamp tangs
Make gaskets for outside front dash access panels
Get the EAA prop balancer and perform dynamic prop balance
Install main gear fairings
Positively retain the pins on main gear fairings
Seal lower antennas with caulk (Comm #2 & Transponder)
Order sandpaper
Order sanding blocks
Get aircraft polished
Record control surface deflections
Compute W&B for flights
Record serial numbers of all avionics
Record service bulletins on here
Document we swung the compass
Safety wire G3x harnesses
Document engine limits / color bands on here
Document fuel calibrations on here
Document fuel flow testing on here
Take screen shots of each EFIS screen and document on here
Get XM radio working
Trial Install GDL39
Link to or attach Bob’s first flight test info
Buy triple-A batteries
Buy power strip
Buy an instrument cover for behind the panel
Buy Cowl Plugs
Buy fuel tank drain plugs
Install forward floor carpet
jamessclarkiv.com 